John Deere 762B Scraper Index:

Safety Signs
Operator’s Station
Instrument Panel
Controls and Pedals
Light System
Break-ln
Pre-Start Inspection
Operating the Engine
Starting
Stopping
Driving the Scraper
Travel speeds
Parking
Operating the Scraper
Control Levers ..
Differential Lock Pedal
Automatic Transmission
Manual Transmission
Operating Tips ..
Transporting
Transporting
Fuel
Engine Oil
Hydraulic, Transmission,
Elevator Gearbox Oil
Grease
Periodic Maintenance
Drive Axle,
Periodic Maintenance Chart
Prepare Machine for Maintenance
Maintenance Records .
Maintenance-AS Required
Drain Fuel Tank Sump
Drain Water Separator Fuel Filter
Check and Adjust Elevator Chain Tension .
Check and Adjust Tire Pressure
Clean Cab Recirculating and Fresh Air
filters
Check Air Filter Restriction Indicator
Check and Adjust Compressor Belt
Tension
Check Fan and Alternator Belt Tension
Maintenance-Every IO Hours or Daily
Lubricate Sliding Floor Lever and Cylinder
Lubricate Draft Frame and Elevator
Pivots
Lubricate Oscillation Hitch, Steering
Links, Cylinder Pivots
Check Hydraulic Oil Level
Check Coolant Level
Check Engine Oil Level
Lubricate Lift Cylinder Pivots
Lubricate Sliding Floor Side Rails ……. ..
Maintenance-Every 50 Hours
Check Transmission Oil Level
Check Drive Axle Oil Level
Maintenance-Every 250 Hours
Change Engine Oil and Filter
Check Elevator Gearbox Oil Level
Maintenance-Every 500 Hours
Change Water Separator Fuel Filter .
Change Drive *ode Oil Filter .
Continued on

Lubricate Axle Drive Shaft
Change Hydraulic Filter
Change Oil Filter
Lubricate Drive Axle Outer Bearings .
Check Air Intake Hoses
Check Brake Accumulator
Check Brake Solenoid Valve
Add Coolant Conditioner .
Change Fuel Filters
Check Battery Electrolyte and Terminals .
Lubricate Transmission Drive Shaft
Change Elevator Oil Filter
Check Oscillation Hitch Pivot Cap Screw
Torque
Maintenance-Every 1000 Hours
Clean, Pack, and Adjust Upper Elevator
Cross Shaft Bearings
Change Transmission Oil
Change Drive Axle Oil .
Clean Engine Crankcase Vent Tube
Adjust Engine Valve Lash (Clearance)
Check Engine Speeds
Adjusting Engine Speed Linkage
Clean, Pack, and Adjust Lower Elevator
Idler Bearings
Clean, Pack, and Adjust Center Elevator
Idler Bearings
Change Elevator Gearbox Oil
Clean, Pack, and Adjust Rear Wheel
Maintenance-Every 2000 Hours
Change Hydraulic Reservoir Oil .
Maintenance
Fuel System
Electrical System
Miscellaneous
Torque Values
Operational Checkout
Gauge and Monitor Checks
Transmission Control Checks
Park Brake, Fuel System, Tachometer,
Hour Meter Checks .
Brake System Checks
Steering System Checks
Driving Checks
Hydraulic Systern Checks
Accessory Checks
Cab Component Checks
Miscellaneous Check
Troubleshooting
Engtne
Electrical System .
Heater-Air Conditioner
Hydraulics
Elevator
Transmission .
Differential Lock
Brakes
Storage
Critne Prevention Tips
Specifications
Machine Numbers