CNH WEIGH LOAD KIT Installation Instructions (90383767)

Out in the yard or on a farm, this kit’s usually hanging off a loader, telehandler, or similar rig that’s moving bulk material all day. These installation instructions walk you through how to mount, route, and hook up the CNH weigh load kit so the machine can actually weigh what it’s lifting. Say you’re loading trucks with grain or gravel: with this manual, you can trace the wiring, install the sensors, and verify the system’s reading close enough that you’re not guessing by the bucket.

Applications & Use Cases

• Install the kit step‑by‑step, so you can isolate each bracket, sensor, and harness and know it’s in the right spot before you tighten anything down.
• Route and secure wiring, checking clearances so it doesn’t rub, pinch, or get ripped off when you crowd the boom or turn full lock.
• Bleed or test any hydraulic connections the kit needs, then verify there are no leaks and the lines are aligned and supported properly.
• Run initial calibration checks, test the weigh function with known loads, and inspect the setup if the readings look off.
• Troubleshoot common install issues, like a dead display or jumpy readings, by tracing power, grounds, and signal paths.

FAQ

Q: Is this a PDF I can search on my laptop or phone?

A: It’s typically supplied as a PDF, so you can keyword search wiring sections or procedures instead of flipping around blindly.

Q: Can I print just the pages I need for the shop?

A: Yes, most folks print the install steps and diagrams they’re working on so they can mark notes, oily fingerprints and all.

Safety Note

Always depressurize and lock out the machine before you crack any hydraulic or electrical connections to install this weigh load kit.

CNH WEIGH LOAD KIT Index:

1 SAFETY INFORMATION
Basic instructions – Important notice regarding equipment servicing. . . . . . . . . . . . . . . . . . . . . . . 1-1
Advice . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2
2 KIT CONTENT
Kit overview. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
3 GENERAL INFORMATION
Basic instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
4 PRE-ASSEMBLY
PREPARING FOR ASSEMBLY
Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
5 ASSEMBLY
Install
Weigh Load. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
6 POST-ASSEMBLY
INSTRUCTIONS
Machine configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1
EN

CNH

90383759 – WEIGH LOAD KIT
CASE CONSTRUCTION
1021G Wheel loader, Stage 5, standard
linkage (ZB) NA
1021G Wheel loader, Stage 5, standard
linkage (ZB) NA
1021G Wheel loader, Stage V, standard
linkage (ZB) – High Performance
1021G Stage V – STD linkage – 2025
Updates
1021G Wheel loader, Stage V, standard
linkage (ZB) [FNH1021GNZHE22170 – ]
1021G Wheel loader, Stage V, standard
linkage (ZB) [FNH1021GNZHE22170 – ]
1021G Wheel loader, Stage V, standard
linkage (ZB) [FNH1021GNZHE22170 – ]
1021G Wheel loader, Stage V, standard
linkage (ZB) [FNH1021GNZHE22170 – ]
1021G Wheel loader Stage 5 STD – New ZF
Transmission Control
1021G Wheel loader Stage 5 STD – New ZF
Transmission Control
1021G Wheel loader Stage 5 STD – New ZF
Transmission Control
1021G Wheel loader Stage 5 STD – New ZF
Transmission Control
1021G Wheel loader Stage 5 STD – New ZF
Transmission Control
1021G Wheel loader Stage 5 STD – New ZF
Transmission Control
1021G Wheel loader Stage V STD – High
Performance
1021G Wheel loader Stage V STD – High
Performance
1021G Wheel loader Stage V STD – High
Performance
1021G Wheel loader Stage V STD – High
Performance
1021G Wheel loader, Tier 4B
(final), standard linkage (ZB)
[JEE1021GNLF253011 – ]
1021G Wheel loader, Tier 4B
(final), standard linkage (ZB)
[JEE1021GNLF253011 – ]
1021G Wheel loader, Tier 4B
(final), standard linkage (ZB)
[JEE1021GNLF253011 – ]
1021G Wheel loader, Tier 4B
(final), standard linkage (ZB)
[JEE1021GNLF253011 – ]
1021G Wheel loader, Tier 4B (final), XR
linkage [JEE1021GNLF253011 – ]
1021G Wheel loader, Tier 4B (final), XR
linkage [JEE1021GNLF253011 – ]
1021G Wheel loader, Tier 4B (final), XR
linkage [JEE1021GNLF253011 – ]
1021G Wheel loader, Tier 4B (final), XR
linkage [JEE1021GNLF253011 – ]
1021G Wheel loader TIER 4B STD – New ZF
Transmission Control Unit
1021G Wheel loader TIER 4B STD – New ZF
Transmission Control Unit
1021G Wheel loader, Tier 4B (final),
standard linkage – High Performance
1021G Wheel loader, Tier 4B (final),
standard linkage – High Performance
1021G Wheel loader TIER 4B XR – New ZF
Transmission Control Unit
1021G Wheel loader TIER 4B XR – New ZF
Transmission Control Unit
1021G Wheel loader, Tier 4B (final), XR
linkage – High Performance
1021G Wheel loader, Tier 4B (final), XR
linkage – High Performance
1021G X-DRIVE Stage V – STD linkage –
2025 Updates – CVT
1121G Wheel loader, Stage 5, standard
linkage (ZB) NA
1121G Wheel loader, Stage 5, standard
linkage (ZB) NA
1121G Wheel loader, Stage V, standard
linkage (ZB) – High Performance
1121G Stage V – STD linkage – 2025
Updates
1121G Wheel loader, Stage V, standard
linkage (ZB) [FNH1121GNZHE22188 – ]
1121G Wheel loader, Stage V, standard
linkage (ZB) [FNH1121GNZHE22188 – ]
1121G Wheel loader, Stage V, standard
linkage (ZB) [FNH1121GNZHE22188 – ]
1121G Wheel loader, Stage V, standard
linkage (ZB) [FNH1121GNZHE22188 – ]
1121G Wheel loader Stage 5 STD – New ZF
Transmission Control
1121G Wheel loader Stage 5 STD – New ZF
Transmission Control
1121G Wheel loader Stage 5 STD – New ZF
Transmission Control
1121G Wheel loader Stage 5 STD – New ZF
Transmission Control
1121G Wheel loader Stage 5 STD – New ZF
Transmission Control
1121G Wheel loader Stage 5 STD – New ZF
Transmission Control
1121G Wheel loader Stage V STD – High
Performance
1121G Wheel loader Stage V STD – High
Performance
1121G Wheel loader Stage V STD – High
Performance
1121G Wheel loader Stage V STD – High
Performance
1121G Wheel loader, Tier 4B
(final), standard linkage (ZB)
[JEE1121GNLF253007 – ]
1121G Wheel loader, Tier 4B
(final), standard linkage (ZB)
[JEE1121GNLF253007 – ]
1121G Wheel loader, Tier 4B
(final), standard linkage (ZB)
[JEE1121GNLF253007 – ]
1121G Wheel loader, Tier 4B
(final), standard linkage (ZB)
[JEE1121GNLF253007 – ]
1121G Wheel loader, Tier 4B (final), XR
linkage [JEE1121GNLF253007 – ]
1121G Wheel loader, Tier 4B (final), XR
linkage [JEE1121GNLF253007 – ]
1121G Wheel loader, Tier 4B (final), XR
linkage [JEE1121GNLF253007 – ]
1121G Wheel loader, Tier 4B (final), XR
linkage [JEE1121GNLF253007 – ]
1121G Wheel loader TIER 4B STD – New ZF
Transmission Control Unit
1121G Wheel loader TIER 4B STD – New ZF
Transmission Control Unit
1121G Wheel loader, Tier 4B (final),
standard linkage – High Performance
1121G Wheel loader, Tier 4B (final),
standard linkage – High Performance
1121G Wheel loader TIER 4B XR – New ZF
Transmission Control Unit
1121G Wheel loader TIER 4B XR – New ZF
Transmission Control Unit
1121G Wheel loader, Tier 4B (final), XR
linkage – High Performance
1121G Wheel loader, Tier 4B (final), XR
linkage – High Performance
1121G X-DRIVE Stage V – STD linkage –
2025 Updates – CVT
1021G+ Stage V STD – Cab Upgrade
1021G+ Stage V STD – Cab Upgrade
1021G+ Stage V STD – Cab Upgrade
1021G+ Stage V STD – Cab Upgrade
1021G+ X-DRIVE Stage V STD – Cab
Upgrade – CVT
1021G+ X-DRIVE Stage V STD – Cab
Upgrade – CVT
1021G+ X-DRIVE Stage V STD – Cab
Upgrade – CVT
1021G+ X-DRIVE Stage V STD – Cab
Upgrade – CVT
1121G+ Stage V STD – Cab Upgrade
1121G+ Stage V STD – Cab Upgrade
1121G+ Stage V STD – Cab Upgrade
1121G+ Stage V STD – Cab Upgrade
1121G+ X-DRIVE Stage V STD – Cab
Upgrade – CVT
1121G+ X-DRIVE Stage V STD – Cab
Upgrade – CVT
1121G+ X-DRIVE Stage V STD – Cab
Upgrade – CVT
1121G+ X-DRIVE Stage V STD – Cab
Upgrade – CVT